Hyundai Santa Fe (DM): Rear Differential Carrier. Repair procedures - Differential Carrier Assembly - Driveshaft and axleHyundai Santa Fe (DM): Rear Differential Carrier. Repair procedures

Removal

1.
Remove the rear wheel and tire (A) from rear hub.

Tightening torque:
88.2 ~ 107.8 N.m (9.0 ~ 11.0 kgf.m, 65.0 ~ 79.5 lb-ft)

Be careful not to damage to the hub bolts when removing the front wheel and tire (A).
2.
Loosen the drain plug (A) and pull out the differential gear oil.

Tightening torque:
49.0 ~ 68.6N.m (5.0 ~ 7.0kgf.m, 36.1 ~ 50.6lb-ft)

3.
Remove the rear driveshaft.
4.
Remove the propeller shaft.
5.
Remove cover (B) as loosen screw (A-4ea).

6.
Disconnect the pressure sensor connector (A) and oil hydraulic motor connector (B).

7.
Remove rear differentia assembly (B) as loosen mounting (A-4ea) after install jack

Tightening torque:
49.0 ~ 68.6N.m (5.0 ~ 7.0kgf.m, 36.1 ~ 50.6lb-ft)

8.
After loosen the bolt and then remove the differential carrier (B) from the coupling (A).

Tightening torque:
56.9 ~ 64.7N.m (5.8 ~ 6.6kgf.m, 42.0~47.7lb-ft)

9.
Install in the reverse order of removal.
10.
Gear oil is injected.

Specified lubricant:
Hypoid gear oil API GL-5, SAE 75W/90 (SHELL SPIRAX X or equivalent)
Oil quantity :
Fill up to the bottom level of the filler plug hole (About 0.53L)

11.
Check the rear alignment.

Rear Differential Carrier. Components and Components Location
Component 1. Rear Differential Carrier 2. Coupling Assembly ...

See also:

Components and Components Location
Component Location 1. Head lamp leveling unit and sensor 2. Head lamp leveling actuator ...

Air Cleaner. Repair procedures
Removal and Installation 1. Remove the engine cover. 2. Remove the air duct(A). 3. Remove the battery. 4. Remove the air cleaner assembly. (1) Disconnect the breather hose (A), the intensifier hose (B). ...

Valve Body. Components and Components Location
Component Location 1. Automatic transaxle 2. Valve body assembly 1. Pressure Control Valve(PCV) adjust screw 2. Solenoid valve bracket 3. Oil temperature sensor 4. Line Pressure Control Solenoid Valve ...