Hyundai Santa Fe (DM): TJ Joint. Repair procedures - Driveshaft Assembly - Driveshaft and axleHyundai Santa Fe (DM): TJ Joint. Repair procedures

Removal

•
Special grease must be applied to the driveshaft joint. Do not substitute with another type of grease.
•
The boot band should be replaced with a new one.
1.
Remove the Front Driveshaft.
2.
Remove the housing circlip (B) from the driveshaft spline (A).
3.
Remove both boot bands from the TJ housing.
4.
Remove the TJ housing (A).

•
Make alignment marks on spider roller assembly (A), joint case (B), and shaft spline (C) to aid reassembly.

5.
Remove the retainer ring (A) from the shaft.
6.
Remove the spider assembly (B) from the driveshaft (A) using the special tool (09495-33000).
7.
Clean the spider assembly.
8.
Remove the TJ boot (A).
•
For reusing the boot (A), wrap tape (B) around the driveshaft splines (C) to protect the boot (A).


Inspection

1.
Check the spider assembly for roller rotation, wear or corrosion.
2.
Check the groove inside the joint case for wear or corrosion
3.
Check the TJ boots for damage and deterioration.

Installation

1.
Wrap tape around the driveshaft spline(TJ) to prevent damage to the boot.
2.
Using the alignment marks (D) made during disassembly as a guide, install the spider assembly (A) and retainer ring (B) on the driveshaft splines (C).
3.
Add specified grease to the joint boot as much as it was wiped away at inspection.
4.
Install the both boot band.
5.
Using the SST(09495-3K000), secure the TJ boot bands.
Clearance (A): 2.0 mm (0.0787 in.) or less

6.
Install the front driveshaft.
7.
Check the front alignment.

TJ Joint. Components and Components Location
Components [LH] 1. BJ assembly 2. BJ circlip 3. BJ boot band 4. BJ boot 5. Shaft 6. TJ boot band 7. TJ boot 8. Spider assembly 9. Retainer ring 10. TJ housing 11. Housing circlip [RH] 1. BJ assembly 2. ...

Dynamic Damper. Components and Components Location
Components 1. BJ assembly 2. BJ circlip 3. BJ boot band 4. BJ boot 5. Dynamic damper band 6. Dynamic damper 7. Shaft 8. TJ boot band 9. TJ boot 10. Spider assembly 11. Retainer ring 12. TJ housing 13. ...

See also:

Tire. Repair procedures
• Using tires and wheel other than the recommended sizes could cause unusual handling characteristics and poor vehicle control, resulting in a serious accident. Tire Wear 1. Measure the tread depth ...

ESC OFF usage
When driving ESC should be turned on for daily driving whenever possible. To turn ESC off while driving, press the ESC OFF button while driving on a flat road surface. WARNING Never press the ESC OFF button ...

Exterior features
Roof rack If the vehicle has a roof rack, you can load cargo on top of your vehicle. ✽ NOTICE If the vehicle is equipped with a sunroof, be sure not to position cargo onto the roof rack in such ...