Hyundai Santa Fe (DM): Troubleshooting
Troubleshooting
|
Symptom |
Suspect Area |
Remedy (Refer to page) |
|
Water leaks from panorama sunroof |
Deteriorated roof lid weatherstrip |
Replace |
|
Excessive roof lid-to-body clearance and improperly fitted weatherstrip |
Adjust |
|
|
Wind noise around Panorama sunroof |
Loose or deformed deflector, gaps in body work |
Retighten adjust or replace |
|
Noise heard when opening/ closing Panorama sunroof |
Foreign particles lodged in guide rail |
Check drive cable and guide rails for foreign particles |
|
Loose guide rails and lid |
Retighten |
|
|
Motor runs but sunroof does not move or moves only partially |
Foreign particles lodged in guide rail |
Adjust or replace |
|
Incorrect engagement of motor pinion with drive cable |
||
|
Decrease in motor`s clutch slipping force |
||
|
Increased sunroof sliding resistance or interference of sunroof with
drive cables, weatherstrip, etc. due tomal adjustment of sunroof |
||
|
Noise in motor (clutch slipping noise from motor when sunroof is fully
opened or closed is not an unusual noise |
Incorrect engagement of motor pinion with drive cable |
Check pinion installation and |
|
Re-tighten motor |
||
|
Worn out or damaged motor pinion bearing |
Replace motor assembly |
|
|
Worn out or deformed drive cable |
Replace |
|
|
Door glass fails to operate up and down |
Incorrect window glass installation |
Adjust position |
|
Damaged or faulty regulator arm or regulator |
Correct or replace |
|
|
Door does not open or close completely |
Incorrect door installation |
Adjust position |
|
Defective door check assembly |
Correct or replace |
|
|
Door hinge requires grease |
Apply grease |
|
|
Hood does not open or close completely |
Striker and latch not properly aligned |
Adjust |
|
Incorrectly installed hood |
Adjust |
|
|
Incorrect hood bumper height |
Adjust |
|
|
Water leak through windshield end rear window |
Defective seal |
Fill with sealant |
|
Defective flange |
Correct |
Special Service Tools
Special Service Tools Tool (Number and name) Illustration Use 09861-31100 Sealany cut-out tool Cutting windshield sealant (use with 09861-31200) 09861-31200 Sealant cutting blade Cutting windshield sealant ...
Body Dimensions
...
See also:
Oil hydraulic Motor(Actuator). Schematic Diagrams
Circuit Diagram ...
Limitation of Active ECO operation
If the following conditions occur while Active ECO is operating, the system operation is limited even though there is no change in the ECO indicator. When the coolant temperature is low: The system will ...
Front Door Trim. Repair procedures
Replacement • Put on gloves to protect your hands. • When prying with a flat-tip screwdriver, wrap it with protective tape, and apply protective tape around the related parts, to prevent damage. • ...
